CrossFit Discussion Board  

Go Back   CrossFit Discussion Board > CrossFit Forum > Equipment
CrossFit Home Forum Site Rules CrossFit FAQ Search Today's Posts Mark Forums Read

Equipment Outfitting a serious gym. Vendors & suppliers. Devices & equipment

Reply
 
Thread Tools
Old 12-27-2014, 10:52 AM   #11
William Henniger
Affiliate William Henniger is offline
 
William Henniger's Avatar
 
Profile:
Join Date: May 2006
Location: Columbus  OH
Posts: 1,059
Re: Bill Henniger! Get in here and answer once and for all!

Putting some rubber etc in the base will reduce the drop impact.

I have personally torn down tons of old bars and inspected the parts inside to see what starts to wear etc. In most bars out there today there are a series of retention washers and snap rings.

These sit in a groove on the bar shaft and hold back the sleeve from coming off the bar.

We have been dropping our bars vertically from 3' on repeat to see if they will hold up from a UPS guy javelin tossing the bar, someone trying to open the bar tube by jamming it on the end etc. There is end float in any bar out there which allows for a slight shift when seated vertically.

I would say storing your bar horizontally on the sleeves with UHMW protection is 100% safe.

Storing the bar vertically especially when you have 100's of clients dropping them in may eventually end up in a deflected internal component. 99% of the time you won't see issue but it just isn't as good as horizontal.

I have seen the internal parts of barbells evolve quite a bit over the past 5 years to offset the reps seen.

Hope that helps

Bill
__________________
Bill Henniger
Rogue Fitness - CrossFit Columbus
Rogue Fitness
  Reply With Quote
Reply


Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is Off
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
how can i answer this Omar Omar Starting 22 02-15-2009 07:52 PM
Anyone with MS willing to answer some questions? Emily Maisannes Health and Medical Issues 0 10-05-2008 12:50 PM
Crossfit is the only answer Cassi Nesmith Stuff and Nonsense 1 04-07-2008 08:41 AM
one of you got to know the answer to this Shane Stoneman Fitness 6 02-21-2008 06:21 PM
I probably know the answer, but.... Chris Hill Starting 2 12-19-2007 11:29 AM


All times are GMT -7. The time now is 09:08 PM.


CrossFit is a registered trademark of CrossFit Inc.